Enhancing Properties of Concrete Mix Using Different Types of Waste Materials: A Review Paper

Authors

  • Waleed Zaid MSc. Gaziantep University, Faculty of Engineering, Department of Civil Engineering, Gaziantep, Turkey Author
  • Ayşe Yeter GÜNAL Dr. Gaziantep University, Faculty of Engineering, Department of Civil Engineering, Gaziantep, Turkey Author

DOI:

https://doi.org/10.55524/ijirem.2023.10.3.12

Keywords:

Coal bottom ash (CBA), waste plastic and fibers, wood waste, soft drink bottle caps, concrete, durability, compressive and tensile strength, slump flow

Abstract

 The proliferation of civilization, industry,  and urbanization, along with population growth, has  contributed significantly to the generation of waste  materials, and this trend continues to this day. Such waste  has far-reaching impacts on both human health and the  environment, leading to environmental degradation and  rendering it non-environmentally friendly. To address  these concerns, many scientists have directed towards the  possibility of using waste materials as a substitute for  some components of the concrete mixture. Numerous  studies have demonstrated the effectiveness of  incorporating such materials such as (coal bottom ash  (CBA), waste plastic and fibers, wood waste, and soft  drink bottle caps) in enhancing concrete's properties,  including durability, compressive and tensile strength,  water content, slump flow, and suitability for reuse in  engineering projects. The use of such materials not only  provides an economic solution but also promotes  environmental preservation by mitigating environmental  problems.  

Downloads

Download data is not yet available.

References

. Abdulkarem, M. A., Rasool, D. A., & Nabhan, B. J. (2020). Utilization of olive and pumice stones to improve the thermal properties of cement mortar. International Journal of Nanoelectronics and Materials, 13(1), 181-188.

. Abed, J. M., & Khaleel, B. A. (2019). Effect of wood waste as a partial replacement of cement, fine and coarse aggregate on physical and mechanical properties of concrete blocks units. International Journal of Integrated Engineering, 11(8), 229-239.

. Afshinnia, K., & Rangaraju, P. R. (2016). Impact of combined use of ground glass powder and crushed glass aggregate on selected properties of Portland cement concrete. Construction and Building Materials, 117, 263- 272.

. Alzaed, A. N. (2014). Effect of iron filings in concrete compression and tensile strength. International Journal of Recent Development in Engineering and Technology, 3(4), 121-125.

. Awoyera, P. O., Ndambuki, J. M., Akinmusuru, J. O., & Omole, D. O. (2018). Characterization of ceramic waste aggregate concrete. HBRC journal, 14(3), 282-287.

. Baalamurugan, J., Kumar, V. G., Chandrasekaran, S., Balasundar, S., Venkatraman, B., Padmapriya, R., & Raja, V. B. (2021). Recycling of steel slag aggregates for the development of high density concrete: Alternative & environment-friendly radiation shielding composite. Composites Part B: Engineering, 216, 108885.

. Daniyal, M., & Ahmad, S. (2015). Application of waste ceramic tile aggregates in concrete. International Journal of Innovative Research in Science, Engineering and Technology, 4(12), 12808-12815.

. Dong, W., Li, W., & Tao, Z. (2021). A comprehensive review on performance of cementitious and geopolymeric concretes with recycled waste glass as powder, sand or cullet. Resources, Conservation and Recycling, 172(May), 105664.

. El-Tawil, S., Abdel-Mohti, A., & Abdeen, S. (2019). Effect of palm leaf sheath fibers on the properties of concrete. Construction and Building Materials, 201, 94-101.

.Ganesan, K., Krishnamoorthy, T. S., & Indira, P. V. (2017). Microstructure and mechanical properties of banana fiber reinforced concrete. Construction and Building Materials, 151, 880-888.

.Gardner, H. C. (1995). Carpet recycling technology. Int. Fiber J., 36.

.Gencel, O., Karadag, O., Oren, O. H., & Bilir, T. (2021). Steel slag and its applications in cement and concrete technology: A review. Construction and Building Materials, 283, 122783.

.Ghadzali, N. S., Ibrahim, M. H. W., Zuki, S. S. M., Sani, M. S. H., & Al-Fasih, M. Y. M. (2020). Material Characterization and Optimum Usage of Coal Bottom Ash (CBA) as Sand Replacement against Concrete Properties. International Journal of Integrated Engineering, 12(9), 9- 17.

.Gil, H., Ortega, A., & Pérez, J. (2017). Mechanical behavior of mortar reinforced with sawdust waste. Procedia engineering, 200, 325-332.

.Guo, Y., Xie, J., Zheng, W., & Li, J. (2018). Tgk d. Construction and Building Materials, 192, 194-201. [16].Hamzah, A. F., Wan Ibrahim, M. H., Jamaluddin, N., Jaya, R. P., & Zainal Abidin, N. E. (2015). Fresh Properties of Self-Compacting Concrete Integrating Coal Bottom Ash as a Replacement of Fine Aggregates. In Advanced Materials

Research (Vol. 1125, pp. 370-376). Trans Tech Publications Ltd.

.Hasim, A. M., Shahid, K. A., Ariffin, N. F., Nasrudin, N. N., & Zaimi, M. N. S. (2022). Properties of high volume coal bottom ash in concrete production. Materials Today: Proceedings, 48, 1861-1867.

.Hossain, K. M. A., & Lachemi, M. (2013). Performance of concrete containing glass powder as a partial replacement of cement. Construction and Building Materials, 47, 1085- 1091.

.Kishore, K., & Gupta, N. (2020). Application of domestic & industrial waste materials in concrete: A review. Materials Today: Proceedings, 26, 2926-2931.

.Kou, S. C., Poon, C. S., & Etxeberria, M. (2011). Influence of ceramic sanitary ware aggregate on properties of fresh and hardened concrete. Cement and Concrete Composites, 33(6), 642-647

.Lim, N. H. A. S., Qin, T. S., Ariffin, N. F., Noh, H. M., & Hussin, M. W. (2020, May). Effect of high-volume coal waste on strength properties of concrete. In IOP Conference Series: Materials Science and Engineering (Vol. 849, No. 1, p. 012053). IOP Publishing.

.Lukowski, P., Horszczaruk, E., Seul, C., & Strzalkowski, J. (2021). Mechanical Strength and Thermal Properties of Cement Concrete Containing Waste Materials as Substitutes for Fine Aggregate. Materials, 14(21), 6334

.Malik, M. I., Bashir, M., Ahmad, S., Tariq, T., & Chowdhary, U. (2013). Study of concrete involving the use of waste glass as partial replacement of fine aggregates. IOSR Journal of Engineering, 3(7), 08-13. DOI 10.9790/3021-0370813.

.Marinković, S. B., et al. (2016). Ceramic waste as a construction material. Construction and Building Materials, 124, 1184-1194.

.Martins, A. C. P., De Carvalho, J. M. F., Costa, L. C. B., Andrade, H. D., de Melo, T. V., Ribeiro, J. C. L., ... & Peixoto, R. A. F. (2021). Steel slags in cement-based composites: An ultimate review on characterization, applications and performance. Construction and building materials, 291, 123265.

.Mehta, K., Sharma, A., Gupta, A., & Bhandari, N. (2018). Study on the properties of banana fiber reinforced concrete. Construction and Building Materials, 160, 398-405.

.Murali, G., Vardhan, C. V., Prabu, R., Khan, Z. M. S. A., Mohamed, T. A., & Suresh, T. (2012). Experimental investigation on fibre reinforced concrete using waste materials. International Journal of Engineering Research and Applications (IJERA) ISSN, 2248(9622), 278-83.

.Nasrudin, N. N., Ariffin, N. F., Hasim, A. M., & Zaimi, M. N. S. (2022). A Review: Utilization of Waste Materials in Concrete. In Materials Science Forum (Vol. 1056, pp. 61- 68). Trans Tech Publications Ltd.

.Noori, A. N., & Numan, H. A. (2020, June). Behavior of Sustainable Reinforced Concrete Building Containing Waste Plastic and Fibers. In IOP Conference Series: Materials Science and Engineering (Vol. 870, No. 1, p. 012094). IOP Publishing.

.Pan, Z., Tao, Z., Murphy, T., & Wuhrer, R. (2017). High temperature performance of mortars containing fine glass powders. Journal of Cleaner Production, 162, 16-26.

.Pandey, A., & Kumar, B. (2019). Preliminary study of cement paste admixed with rice straw ash, microsilica & rice straw ash-microsilica composite. Int. J. Recent Technol. Eng, 7, 302-307.

.Pang, B., Zhou, Z., & Xu, H. (2015). Utilization of carbonated and granulated steel slag aggregate in concrete. Construction and building materials, 84, 454-467.

.Prasanna, P. K., & Rao, M. K. (2014). Strength variations in concrete by using E-waste as coarse aggregate. International Journal of Education and applied research, 4(2).

.Rashid, K., Razzaq, A., Ahmad, M., Rashid, T., & Tariq, S. (2017). Experimental and analytical selection of sustainable recycled concrete with ceramic waste aggregate. Construction and Building Materials, 154, 829- 840.

.Rasool, D.A., Abdulkarem, M.A., & Jasem, M.H. (2022). Improvement of the Cement Mortar Properties using Recycled Waste Materials. International Journal of Nanoelectronics and Materials, 15(2), 155-162.

.Saad, M., Agwa, I. S., Abdelsalam Abdelsalam, B., & Amin, M. (2022). Improving the brittle behavior of high strength concrete using banana and palm leaf sheath fibers. Mechanics of advanced materials and structures, 29(4), 564-573.

.Saxena, S., & Tembhurkar, A. R. (2018). Impact of use of steel slag as coarse aggregate and wastewater on fresh and hardened properties of concrete. Construction and Building Materials, 165, 126-137.

.Siddique, R., Aggarwal, P., & Aggarwal, Y. (2012). Influence of water/powder ratio on strength properties of self-compacting concrete containing coal fly ash and bottom ash. Construction and Building Materials, 29, 73- 81.

.Singh, M., & Siddique, R. (2013). Effect of coal bottom ash as partial replacement of sand on properties of concrete. Resources, conservation and recycling, 72, 20-32.

.Singh, M., & Siddique, R. (2015). Properties of concrete containing high volumes of coal bottom ash as fine aggregate. Journal of Cleaner Production, 91, 269-278.

.Soomro, B., Mangi, S. A., Bajkani, R. A., & Junejo, A. Q. (2021). Recycling of ceramic tiles and marble powder waste as partial substitution in concrete. Neutron, 20(2), 128-137.

.Taha, R., Nounu, G., & Al-Kutti, W. (2017). The effect of using waste glass powder on the mechanical properties of cement mortar. Journal of Cleaner Production, 141, 22-32.

.Tobi, A. (2022). Compressive Strength Properties of Cassava Peel Ash and Wood Ash in Concrete Production. International Journal of New Practices in Management and Engineering, 11(01), 31-40.

.Vasudevan, G. (2013). Seri Ganis Kanapathy pillay, Performance of using waste glass powder in concrete as replacement of cement. American Journal of Engineering Research (AJER), 2320-0847.

.Wang, Y. (1997). Properties of concrete reinforced with recycled carpet waste fibers. Brittle Matrix Composites 5, 179-186.

.Wang, Y. (1998). An overview of activities on recycling of fibrous textile and carpet waste at the Georgia Institute of Technology. Ecotextile’98: Sustainable Development, 165.

.Xu, Y., Chen, X., & Zhang, Y. (2018). Mechanical properties and microstructure of high-volume glass powder concrete. Journal of Cleaner Production, 171, 870-879.

Downloads

Published

2023-06-30

Issue

Vol. 10 No. 3 (2023): International Journal of Innovative Research in Engineering & Management (JUN) 2023

Section

Articles

How to Cite

Enhancing Properties of Concrete Mix Using Different Types of Waste Materials: A Review Paper . (2023). International Journal of Innovative Research in Engineering & Management, 10(3), 67–81. https://doi.org/10.55524/ijirem.2023.10.3.12
Crossref
Scopus
Google Scholar
Europe PMC